Q4 2022 Spirit AeroSystems Holdings Inc Earnings Call
Speaker 1: Thank you, Glenn, and good morning everyone. Welcome to Spirit's fourth quarter and full year 2022 results call.
Speaker 2: I'm Aaron Hunt, Director of Investor Relations, and with me today are Spirit's President and Chief Executive Officer Tom Jindhilly, Senior Vice President and Chief Financial Officer Mark Szczynski, Executive Vice President and President of Defense and Space Division Dwayne Hawkins, and Spirit's Executive Vice President, Chief Operating Officer, and President of Commercial Division Sam Marnick.
Speaker 3: After opening comments by Tom, Dwayne, and Mark regarding our performance and outlook, we will take your questions. Before we begin, I need to remind you that any projections or goals we may include in our discussion today are likely to involve risks, and cleaning those detailed in our earnings release, in our SEC filings, in the forward looking statement at the end of this web presentation, and reference in our call today. In addition, we refer you to our earnings release and presentation for disclosures and reconciliation of non- GAAP measures we use when discussing our results. And as a reminder, you can follow today's broadcast and slide presentation on our website at www.investor.spiritarrow.com. With that, I would like to turn the call over to our Chief Executive Officer, Tom Gentilly.
Speaker 4: Thank you, Aaron, and good morning, everyone. Welcome to Spirit's fourth quarter and full year 2022 results call. Last year, we saw domestic travel continue to recover across the globe. The U.S. was the best performing market, where air traffic was 2% below the 2019 level. And in China, we were encouraged to see some travel restrictions lifted.
Speaker 5: and the 737 MAX return to service. Domestic air travel favors narrow body aircraft like the A320 and the 737 MAX, both of which logs several significant new orders during the year. The orders and additional backlog provide support to Airbus and Boeing's plans to increase narrow body production rates further.
Speaker 6: We are encouraged by the continued demand, which we expect will benefit spirit since 85% of our backlog is tied to Neurobody Aircraft.
Speaker 7: While demand remains robust, we experienced a number of challenges as we increased production rates during 2022.
Speaker 8: We had to hire a significant number of new employees who are taking time to reach the same level of proficiency as the workers we had prior to the pandemic.
Speaker 9: We also experienced higher levels of attrition with the new employees we hired. In addition, our suppliers encountered similar challenges, which resulted in higher levels of part shortages throughout the year. We also encountered higher levels of inflation.
Speaker 10: Despite these challenges, we managed to increase our production rates across several major programs by 27% overall.
Speaker 11: On the 737 program, we managed through the challenges as production increased from 162 units in 2021 to 281 units in 2022, a 73% increase.
Speaker 12: to support the recovery and the expected higher level of production in 2023.
Speaker 13: We began hiring additional headcount in the fourth quarter, which drove additional cost. But it is an investment to get ready for the production rate increases in 2023.
Speaker 14: While we expect to see ongoing supply chain challenges and issues as we stabilize production, our December 737 production was 40 units.
Speaker 15: demonstrating our capability to produce at higher rates.
Speaker 16: In 2023, we plan to produce about 420 737 shipsets, which includes the units behind schedule from 2022. In January , we delivered 33 737 units.
Speaker 17: Turning to our wide body programs.
Speaker 18: The 787 program navigated through challenges last year and we delivered 20 units to our customer.
Speaker 19: Our 787 production resumed with a new bill process to address the fit and finish requirements applicable to all the partners on the program.
Speaker 20: After completing a few units with the new process, we have found more labor per unit is needed than originally expected, which is one of the reasons driving an additional forward loss on future units this quarter.
Speaker 21: It is also taking us longer than we expected to rework the STORRAT 787 units.
Speaker 22: We now believe we have incorporated what is needed for the 787 fit and finish requirements in the new bill process and rework.
Speaker 23: On our A350 program, we continue to see disruption driving increased cost pressure. During the year, we saw continued disruptions from the supply chain.
Speaker 24: The transfer of parts and the ramp up of production put the program behind schedule. We have initiated our recovery plan. However, recovery costs included expedited shipping of components to support our customers' production are resulting in additional forward loss.
Speaker 25: Mark will walk you through the details of the forward losses on these two programs in his section.
Speaker 26: We continue to support Airbus on their Narrow Body programs. Our production was in line with demand from Airbus and we expect to continue to produce to remain in sync with their production plans.
Speaker 27: In 2023, we plan to produce between 650 and 680 A320 units and about 80 A220 units.
Speaker 28: In looking at our widebody programs for 2023, we will support our customers as they increase their production rates to support the international traffic recovery.
Speaker 29: On the 787 program, we expect to produce between 40 and 45 787 chipsets.
Speaker 30: On the A350 program, we plan to remain in sync with Boeing, excuse me, with Airbus production as they increase from five to six aircraft per month and plan to produce about 60 units on the A350.
Speaker 31: Now let's turn to our defense and aftermarket businesses.
Speaker 32: On defense and space, our segment president, Wayne Hawkins, is retiring from his current role in just a few weeks and will hand off the segment to Mark Mecliffe.
Dwayne and the team have done a great job in building Spirit's Defense in Space segment, and we wanted to give him an opportunity to take you through some of the many highlights from 2022. Dwayne?
Thanks, Tom. In 2022, the Defense and Space team did a really good job executing on existing programs and winning some new ones.
across our five growth areas, hypersonics, UAS, next generation effects.
Next generation aircraft and space. We expanded relationships with current customers and created some new ones.
The defense and space segment revenues were up a little over 11% from 2022.
as 650 million with approximately 11.2% margin.
We had solid contributions from the P8 and KC46 programs.
On the CH-53K program, we began preparing for full rate production by developing our rate production tooling and manufacturing build plan, while also delivering aparenal repl?ars.
And in December , we had the opportunity to attend the B21 on Daling.
to celebrate the team's contributions to this important new defense platform.
Spirit is one of the seven partners on the B21 program.
We have a strong pipeline of defense and space opportunities that we continue to pursue. In 2022, the team won multiple classified and unclassified programs that could eventually result in significant revenue for spirit. One of the first in the year was a win for the B-52 commercial engine replacement program.
where spirit will build the struts and the cells for approximately 78 aircraft that are in service.
We were also selected to support the KC-135 Horizontal Stabilizer Program.
which will help extend the life of an aircraft we often see racing the skies here in Wichita.
Another win in the year was the Strategic Partnership Agreement for the Sierra Space Shooting Star cargo module. In addition to the shooting star, Sierra Space and Spirit will work together to advance a family of cargo modules and service modules.
And finally, we are closely monitoring the protests of the Army Flower Award to our partner Bell Helicopter.
and look forward to supporting them on this exciting new program.
Spirit is proud is proud to be a member of Team Vellor.
The Spirit National Defense Prototype Center, NDPC, continues to support development, prototyping, and industrialization capabilities to support our growth strategy. In addition to the NDPC, we have continued to repurpose some of our excess widebody capacity to defense applications. We also have trained all producers that we do Today'sAnd, overall, a vast amount of work now has gone on to deliver theline production by Tony FSB, including Honca Music, a track
So far, approximately 1.2 million square feet in which a tile has been transitioned to our defense and space business. This includes the establishment of our Defense Manufacturing Center, which will provide significant classified machining capability with full size, determined as assembly accuracy.
The ability of our team to be involved from the initial concept design to production is critical to optimizing how we can support customers on future programs.
We closed out the year with the acquisition of Team, a small company in Rhode Island that has a great set of technologies that complements our capability.
The 100,000 square foot facility and the 35 talented individuals bring some unique 3D composite weaving technology and equipment.
to enhance our portfolio that will support hypersonic weapon development, as well as other new product development opportunities.
I'm proud of the defense of space business that we've been building at Spirit. It's on track to our target of $1 billion in defense of space revenue by 2025 with 12 to 14 percent segment margins. And I look forward to working with our new Spirit and Defense of Space leader, Mark Miklos, as he takes over on April 1. Back to you, Tom.
space business that we've been building at Spirit. It's on track to our target of $1 billion in defense of space revenue by 2025, with 12% to 14% segment margins. And I look forward to working with our new Spirit and Defense of Space leader, Mark Miklos, as he takes over on April 1. Back to you, Tom. Thanks, Wayne.
Our aftermarket business also had a strong year with revenue growth of 30% at 19% margins.
The aftermarket team continued to build out our strategy to expand our MRO capabilities in key geographic regions.
In Asia, we establish multiple ways to support customers in that region.
In April , we signed an agreement with Gammaco to be the Spirit Authorized Repair Center in China.
Then, in September , we formed a joint venture with Evergreen Technologies Corporation in Taiwan and signed an MOU with Malaysia Airlines Burhead to establish repair services for nacelles and flight control surfaces.
We also signed a partnership with Boeing to provide repair services for the MAX on flight control surfaces, nacelles, and thrust reversers.
We close out the year with an MOU with Duramco, the engineering arm of Dubai Aerospace Enterprise, to explore how to bring a range of composite and metallic aerostructure repairs and services to customers in the Mideast region.
We continue to target $500 million of revenue for our aftermarket business with margins in excess of 20% by 2025.
I'll now turn it over to Mark to take you through more details on our results. Mark
Thank you, Tom. And good morning, everyone.
We experienced significant pressure in 2022 due to production schedule volatility, a constrained supply chain, ongoing inflation, and labor pressures including shortages, high levels of attrition, and increased training for our new hires.
These challenges have resulted in higher than anticipated costs and disruptions in our factories.
We expect some of these pressures to continue into 2023, particularly those related to the supply chain and training new employees.
We enter 2023 strongly focused on execution and getting our factories and people in place to stabilize and support higher production rates.
Now let me take you through the details of our 2022 financial results.
Let's start with revenue on slide two.
Revenue for the year was $5 billion, up 27% from 2021.
This improvement was primarily due to higher production on the 737, A320, and A220 programs, as well as increased aftermarket and defense in space revenue, partially offset by lower production on the 747 and 787 programs.
The defense and space segment had a strong year with top-light growth of 11%.
increasing revenue by about $65 million.
Aftermarket also displayed strong execution with revenue growth of 30% over 2021 levels.
Turning to deliveries, overall narrow body deliveries in 2022 were 37% higher than 2021.
We delivered 190 more 737 units.
and 124 more A320 units compared to 2021.
Alternatively, wide-body program deliveries were down 6% compared to 2021, mainly driven by 17 less 787 units in 2022.
Overall, 2022 deliveries increased 27 percent year over year.
Now let's turn to earnings per share on slide three.
We reported earnings per share of negative $5.21 compared to negative $5.19 in 2021.
excluding certain items.
adjusted EPS was negative $2.81 compared to negative $3.46 in the prior year.
Operating margin was negative six percent.
compared to negative 12% in 2021.
The improvement over 2021 is due to higher production rates.
specifically on the 737 program.
partially offset by continued disruption in our factories, resulting from part shortages and labor challenges, which led to auto sequence work and operational instability.
Full year Ford losses total 250 million and unfavorable cumulative catch up adjustments were 28 million.
This compared to 242 million of Ford losses and 5 million of unfavorable cumulative catch-up adjustments in 2021.
Specifically related to the fourth quarter of 2022, we incurred $114 million of forward losses.
which were primarily driven by the 787 and A350 programs.
The 787-4 loss of 38 million recorded in the fourth quarter was largely driven by higher cost estimates related to restarting the factory in ramping production as well as new build requirements on each unit resulting from the fit and finish issues.
We forecast the cash impact from this loss to occur over the next four years.
The A350 charge of $667 million in the fourth quarter of 22 was a result of additional costs related to labor and park shortages.
manufacturing quality issues, and additional freight to support our customer deliveries.
In addition, during the fourth quarter, we experienced disruption resulting from transferring the production of parts from a supplier into our Kinston facility.
This resulted in additional disruptions to our factory, and we have now initiated a recovery plan, which will result in additional costs.
Approximately 40 million of that forward loss will have an impact to cash in 2023.
Additionally.
in the fourth quarter of 2022, we recognized unfavorable cumulative catch-up adjustments of $59 million.
primarily driven by the 737 and A320 programs.
On the 737 program, we experienced disruptions due to labor inefficiencies and continued part shortages, which exacerbated behind schedule hours.
and our auto sequence worked.
To catch up and prepare for the next rate break, we've made the decision to accelerate the hiring and training of employees to support a rate of 42 aircraft per month.
This investment has a near-term impact on the program's profitability and cash flow, but we believe it is important to improve spirits production efficiencies as well as prepare for higher production rates in the future.
The A320 program's unfavorable adjustment was driven by operational and supply chain disruptions.
increased costs related to material, freight, and labor.
2022 earnings also included 157 million of excess capacity costs.
A decrease of 60 million over 2021.
Other expense was $14 million compared to other income of $147 million in 2021.
This variance was primarily due to pension plan termination activities that were undertaken separately in each of the years.
2021 included a curtailment gain of 61 million resulting from the closure of the defined benefit plans acquired as part of the Bombardier acquisition.
and in 2022.
we terminated the frozen U.S. pension value plan A, which resulted in non-cash charges of $108 million.
We anticipate additional pre-tax non-cash charge in the first quarter of 2023 for the final settlement accounting, as well as tax-related charges for the income and excise taxes, which we expect to conclude no later than the second quarter.
Now, turning to free cash flow on slide 4.
Recasable usage for the year was $516 million, in line with the range we communicated on our third quarter call.
Free cash flow in both years were impacted by several large one-time cash items, including a $300 million tax refund received in 2021.
A payment of $154 million to the Belfast pension plan in 2021.
as well as the repayment in 2022 of 123 million Boeing 737 advance that we received in 2019.
In addition,
2022 free cash flow was negatively impacted by production schedule changes.
the Ukraine Russian conflict
headwinds from forward losses, labor constraints.
supply chain part shortages, and inflationary pressures.
There are also several other cash items in 2022 that will not recur going forward, including $38 million of a grant received.
from the AMJP program and $27 million of net pension-related benefits from the termination of the Pension Value Plan B.
Looking to 2023.
We plan to deliver approximately 420 737 units.
and 650 to 680 A320s during the year.
which will be the largest driver of cash flow improvement.
Additionally,
2023 will be positively impacted by $120 to $140 million of surplus cash from the termination of the Pension Value Plan A.
Partially offset by higher interest payments.
and a previously reserved litigation payment.
litigation payment which has been appealed.
incorporating all items.
including the pension surplus cash.
We are targeting 2023 free cash flow to be better than break even.
free cash flow to be better than break even. Reflected
estimated capital expenditures in the range of 125 million to 150 million.
We anticipate the first quarter free cash flow to be the weakest.
cash flow improving throughout the last three quarters of the year.
partially due to normal seasonality of our cash flows.
With that, let's now turn to our cash and debt balances on slide 5.
We ended the year with $659 million of cash and $3.9 billion of debt.
These balances reflect items I previously listed as drivers to free cash flow. In addition to the 319 million payment that settled a repable investment agreement in the first half of 2022 and the refinancing activity we completed during the fourth quarter of 2022, including refinancing and extending maturities.
on $800 million of existing debt and upsizing by $100 million.
Now let's discuss our segment performance starting with the commercial segment on Flight 6.
In 2022, commercial revenue was $4.1 billion, an increase of 30% compared to 2021, primarily due to higher production volumes on the 737, A220, and A320 programs partially offset by lower production on the 747 and 787 programs.
Operating margin was negative 2% compared to negative 7% in 2021.
driven by higher volumes on the 737.
As I previously mentioned, the changes in estimates during the year included four losses of $244 million and unfavorable cumulative catch-up adjustments of $30 million.
In comparison, during 2021, the segment recorded 227 million of forward losses and 6 million of unfavorable cumulative catch-ups.
The segment had excess cost of $150 million compared to $207 million in 2021.
Additionally, the segment recognized 38 million of charges related to the Russian sanctions, which had an impact during 2022.
Now let's turn to the defense and space segment on slide 7.
Defense and space revenue grew to $650 million, or 11% higher than 2021, due to higher development program activity.
The Fence and Space revenue grew to $650 million, or 11% higher than 2021, due to higher development program activity and increased PA production.
Operating margin for the year increased to 11% compared to 8% in 2021.
The improvement was due to higher classified program profit and the absence of non-recurring charges taken into 2021.
In 2022, the segment recorded four losses of $6 million and excess capacity costs of $8 million, compared to four losses of $14 million and excess capacity costs of $11 million in 2021.
For our aftermarket segment results, let's turn to slide eight.
Aftermarket revenues were $311 million, up 30% compared to 2021, primarily due to higher spare parts sales, as well as higher maintenance, repair and overall activity.
Operating margin for the year increased to 19% compared to 21%.
in 2021 due to one-time inventory adjustment charges as well as losses of $4.2 million related to the Russian sanction.
2022 was a more challenging year than we expected. Production schedule volatility, a disrupted supply chain, labor constraints, and ongoing inflation resulted in increased costs, forward loss charges, and instability in our factories.
Despite the many challenges during the year, there were several things that went right.
Many of our financial metrics have reflected continued improvement over the last two years, and I expect a recovery to continue going forward.
We have announced wins in our defense and space and aftermarket segments.
And we have restructured our debt, including executing on refinancing activity, which has extended our riturities.
Restructured our debt, including executing on refinancing activity, which is extended our returities, and settled a repiable investment agreement.
As we enter 2023, we are working with our suppliers and our internal teams to stabilize production.
and position ourselves for higher production rates.
The focus on operational execution.
as well as optimizing our costs, should enable us to improve profitability and cash flow as we move throughout 2023.
Now, let me turn it back over to Tom for some closing comments.
Thanks, Mark. And remain strong in the global aerospace industry.
However, it was a challenging year to navigate the supply chain and other challenges we faced.
We worked hard to make progress to stabilize at higher production rates and we were pleased to close the year with some positive results which will provide a strong foundation for 2023.
As we enter 2023, we expect free cash flow to be positive as we benefit from increased narrow body production rates and continue to work on improving our labor productivity and stabilizing our supply chain.
We have seen some improvements from the depths of the pandemic, but expect that there will still be some volatility as the recovery continues.
After four challenging years since the first MAX crash in 2018, we see some positive trends in the market that will benefit Spirit.
Domestic traffic has recovered a 98% of what it was compared to 2019 levels, which will benefit narrow body aircraft production.
and 85% of spirits backlog is narrow body aircraft.
Boeing has said that they do not want to develop a new aircraft until 2035, which is good news for Spirit, since the MAX and all of our other Boeing programs will continue for many years to come.
Boeing has said that they do not want to develop a new aircraft until 2035, which is good news for Spirit, since the MAX and all of our other Boeing programs will continue for many years to come. China has started to fly the MAX again.
Both China Southern and Hainan have both made flights, which is very good news for that program and offers upside as China brings the stored MAX aircraft out of storage.
starts taking deliveries again, and then eventually places new orders.
Following just announced that they're starting a 4th 737 Max production line in Everett, which highlights their commitment to increasing rates on the max.
and that's Spirit's biggest and most profitable program.
And organic diversification in our defense and space segments and aftermarket is progressing well.
We also have some good growth opportunities in commercial, including freighters for Airbus hand-bowing, eVTOL opportunities, and other machining opportunities.
For 2023, our three primary objectives will be what we are calling the three R's. First, we must realize the production rate increases across all of our programs while maintaining a safe workplace and improving quality.
Second, we have to reduce structural cost to position spirit to be profitable and cash low positive, even if production rates do not go up as fast as currently projected.
We have assigned a senior executive and team of leaders to our cost optimization project focused in three areas operations infrastructure and supply chain
In the infrastructure area, our target is to reduce 1,000 indirect positions.
from our 2023 headcount plan through a combination of reductions, attrition, and closing open hiring requisitions.
Third, we want to re-energize our workforce so that we are ready to meet the challenges ahead as fast as we can, as we face the fastest growing rates in the history of the aviation industry.
With that, we will be happy to take your questions.
Thank you.
Ladies and gentlemen, if you'd like to answer questions, please press the full mobile one on Typhoon Keypad now.
Due to the low participant, please leave it to one question at a time. Thank you.
Our first question comes from David Strauss from Barclays. David, your line is now open. Great, thanks. Good morning.
David Strauss from Barclays. David, your line is now open. Great, thanks. Good morning.
Free cash flow. So I guess, prior to today, you were seeing better than break even without the pension cash gain. You're seeing better than break even, but including that. You're seeing better than break even without the pension cash gain. So I guess, prior to today, you were seeing better than break even without the pension cash gain.
I guess what changed in terms of your forecast, because it looks like now, you know, 420 on the max would be better than what you were talking about before, which I think was 31 a month. So if you can just help us reconcile what changed now versus your prior pre-cash flow guidance. And as for your 13 days off, and I can talk to you about it again, just let me know. What do you do?
Right. Yeah, so thanks, David. A lot of things have changed, really, since we made some of those forecasts. We have seen higher costs across the board in things like freight, utilities, and logistics, as well as labor. In addition, as we are looking at the glued to Fourth chuckles a month, agencies had seen some large investments in the
just the overall cost for production.
those are going up. So we mentioned that we've, for example, hired now up to 42 aircraft per month on the MAX program. That's in advance of any rate increases to that level. And the reason we did that was to prepare ourselves for higher rates in the future. That means it's a higher investment now. And so those are the types of pressures and headwinds.
that make us to conservatively estimate that we'll be break even now, including the pension benefit of $120 to $150 million.
conservatively estimate that will be break even now including the pension benefit of $120 to $150 million. Mark anything else?
David, I think Tom summarized it right. We continue to see instability in our factories. We're bringing in much higher headcount to support.
our 737 production and that is going to have a negative impact on 2023 cost and cash flow and so that is the first headwind in investment we need to make the drive stability and the factory and meet our delivery commitments to our customer. Secondly I had mentioned some challenges in our building.
facility and we took an additional 60 plus million forward loss and I had mentioned that that recovery is going to require us to hire more people
expedite shipments and incur some additional costs to support our customer requirements and indicated that that cash impact will be $40 million which was not incorporated in our in our last overall discussion.
And then I'll also tell you as we think about the supply chain that we have here, I think it's going to put a little bit of pressure on our working capital. We're needing to bring in additional inventory, provide some buffers ahead of the rate breaks.
probably more so than we anticipated as the stability continues here. So, you know, at this point in time, it's early in the year. We've just started. We want to make sure that, you know, we're providing you with some information that we can meet and we'll continue to update you as we progress throughout the year.
Thank you. Thank you, David.
Our next question comes from Kai Von Rumor from Kuo Wen. Kai, your lines are open.
Yes, thanks so much.
The pattern of cash flow throughout the year may be give us some color there. Is it all three quarters of red ink and then one quarter of black ink if you're just break even? And then related to that, you delivered 33, 7, 3, 7s in January .
Is that a sustainable rate or is that just, you know, they were sort of pretty much done in the fourth quarter and because the inventory bulged and now they're just getting out the door so that's kind of tough to build so that, you know, you're not going to get a huge benefit from delivering planes in the first quarter. Thank you.
So, Kai, as we said a little bit earlier, cash flow in Q1 is going to be our toughest quarter.
And then the cash flow in Q2, 3, and 4 should be positive. That's the pattern that we are anticipating. Normally the Q1 is our hardest because of several one-time cash payments that happen just in the first quarter for seasonality standpoint.
In terms of the production level for January , 33 is a run rate projection. As we said, we're going to produce about 420 max units for 2023. The plan for Q1 is about 105, so it's just basically right on schedule throughout the year.
We do expect some rate breaks in the back half of the year, but the total again is 420 units with 105 in Q1 and we started off the year with 33 in January .
If you mention the one-timers in the first quarter, could you give us some color on what those are? Because interest basically gets hit in the second and fourth quarter. Thank you.
Yeah, sure, Kye. I mean, the first quarter always is typically, from a seasonality standpoint, our worst cash flow. A lot of that has to do with shutting down production at the end of the year. And so what happens is we start off the year, we pay bills.
but we go the first week or two without any cash receipts from all of our customers. And so I would say that is the biggest negative as it relates to our seasonality in the first quarter. Less seven to ten days of the year, we don't make any deliveries, and therefore it takes a couple of weeks for us to start delivering units and starting to get paid.
that get paid out in the first quarter that don't repeat. But you're correct as it relates to the big head and the widths on cash as it relates to the interest is going to occur in the second and fourth quarters.
Thank you so much.
Thank you so much.
Thank you Kai. Our next question comes from Shira from Jeffries.
Sheila, your line is now open.
Hi, thank you. So I just wanted to ask, thanks guys.
You know, how are you thinking about the cash burn on the 787?
just given the forward losses and what the contribution is in 2023 given the target to deliver between 40 and 45 ships up.
Can you hear me?
Yes. We can hear you Sheila. Yep. So as we've said... Okay, you heard the question. Yeah.
Yes, 787 is cashburned. 787 right now still continues to burn cash on a per unit base. Part of it is related to a Boeing advance from several years ago that we send with each ship set. So it's about $450,000 per unit.
And then on top of that, as I mentioned, with this new fit and finish, the set of requirements in the bill process is resulting in some more hours, which is creating some further drag in terms of the overall 787 program. We've reflected that in the forward loss that we announced in this quarter.
But the 787 does continue to be a challenging program. We do have a price step up at line unit 1405, where we go up to a higher price with Boeing. But until then, the program is going to continue to be negative as we continue to work our cost reduction programs.
I would just just add I think you're you're going here if you think about 20
As Tom said, we're in a forward loss. Everybody understands that our costs are higher than the price. And $7,87 consumes cash. So when you think about 2022, for most of the year, for a big portion of the year, production was stopped.
And so we were incurring costs. At the end of the day, you couldn't completely shut down the place. You still had to pay bills and some of the employees.
So our cost per unit at the lower production in 2022 was significantly higher. As we move into 2023, we are going to double production, which will help from a fixed cost standpoint and help reduce our cost per unit. And so when we think about cash flow, the consumption that we had in 2022 versus 2023, we are going to double production.
we're going to consume at 45 units.
I would say there's a little bit of pressure on cash flow in 2023 compared to 2022.
But that's how things shape up. We're going to bring the cost pre-unit down production starts back up. We're still losing money on it, just a little less than what we lost in 2022.
if that helps provide a little bit more clarity.
if that helps provide a little bit more clarity. Yes, thank you.
Thank you Sheila.
With our next question comes from Ken Herbert from RBC. Can your lines now open?
Yeah. Hi. Good morning.
Morning. Hey, um, Mark or Tom, I just wanted to see if you could clarify it sounds like on a per unit basis on the 737 you talked in the past about break even at 31 a month Looks like that numbers just creeping up with with obviously the incremental cost around staffing and
supply chain disruptions. Can you level set us now on how we should think about that for the the 737? Maybe sort of where we are today and where you expect it to be at the end of the year?
Well, I think it is true that we are seeing higher levels of cost on the 737 program right now in particular because we've overstaffed it to get ready for higher rate breaks. And we've also seen some increases in costs in things like utilities and logistics and even some labor costs.
as well as supply chain. So, you know, we said that in the past that once we got to 31 aircraft per month, that would be break even. This year, we're gonna basically, we started the year off at 31 and we're gonna continue. We have a couple of rate breaks later in the year, and we're saying that we're gonna be break even. So we do have some additional units in this year.
but we'll see how everything flows out in terms of how much better we can do. But I would say that we said that 31 aircraft per month, we get back to break even. This year, we're going to be consistently at 31 aircraft per month, plus some at the back end of the year, and we will be break even. All that said, as I said, there are some higher costs, no doubt about it.
in the difference between being break even in the situation where a now is.
the instability in the factory.
instability in the factory. Once we get to stable
We get the out-of-sequence work built down.
out of sequence work built down and behind schedule within the control limits.
We'll be right back to our previous expectations of being break even at 31, but there's a lot of cost at this point in investment that we're making.
to drive the instability down in the factory, to get the factory back.
within its control limits.
And that's why we're making the investment now here in the first quarter.
to get that cost down so that we're in a good position to generate positive cash flow going forward and to make sure that we're more than well prepared for the next breaks that happen in the back half of the year.
So the headcount we're investing in right now is to make us capable of 42. And that's where we expect to end the year. So by having those individuals in place now, they've got their training, they get experience on the job, and we'll be ready for those breaks as they happen.
Great, thank you. Just one quick follow-up. Is the instability in the factory, it sounds like it's predominantly related to just the surge in hiring or having to do to support rate down the road, but are you still seeing issues with supplier disruption and delays, or is it predominantly...
just labor and the ramp up and training associated with that? No, it's both Ken. You know, certainly bringing all the new labor on and getting them trained.
is a factor and we have seen higher levels of attrition and it takes time for people to get up to the levels of productivity that we were at back in 2018 and 2019. They're getting there, it's just taking some time. But there's no doubt that there's also still supply chain disruption. We're seeing shortages probably two or three times higher than when the factory is.
in steady state. And when you have those kind of supply chain shortages, it creates traveled work, it creates disruption in the factory, it exacerbates all the other issues. So it really is both things. It's the labor, but it's also the supply chain shortages. I would say though that the supply chain situation is under better control than we were last year.
There are still challenges, but it's definitely improving. We can see that, but we just got to stay laser focused on it.
Thanks, Tom. Thanks, Mark.
Great. Thanks, Tom. Thanks Mark.
Our next question comes from Steve Saffman from JP Morgan.
Set your lines now open.
Hey, thanks very much. Good morning everyone.
Tom, I was wondering if you could talk a little bit about the guidance for 737 this year, the deliveries. In the past, there have been plans for rate breaks later in the year that haven't really materialized. We gotta keep going.
And that's left you guys in a tougher position in terms of kind of what you've told the investor community. So can you talk a little bit about your level of confidence in the rate breaks for later this year versus in the past?
Well, you're right. The schedules have been more volatile over the past couple of years, but we've worked very closely with our customer Boeing in this case to establish what the production rates are going to be for 2023. And they've been very sperm and committed to saying that that's what they will take from us and by now.
So, I would say there has been more volatility, but we're further along in the process and post-pandemic, and we do expect with a fairly high degree of certainty at this point that the projections that we have right now for the 420 units is what we'll deliver this year.
Thanks very much.
Great. Thanks. Thanks very much. Thank you, Seth.
Our next question comes from George Sapiro from Sapiro Research. George, your lines are open.
Oh yes, good morning.
Inventory was up 80 million in the fourth quarter from the third. Is that all pretty much due to the 19.37 deliveries that were missed?
Inventory was up 80 million in the fourth quarter from the third. Is that all pretty much due to the 1937 deliveries that were missed? George, is the
As always, you're very...
your intuitive as it relates to the numbers you know our numbers very well. I would say for the most part we had expected to make those deliveries and burn that inventory down. We brought the parts in to support 300 chip sets on the 737.
You know, a lot of them are pretty well down the road by the end of the year, but we just, you know, with the disruption and some shortages, we just couldn't push those out the door. So the biggest driver to that growth and inventory between the third and fourth quarter was due to the fact that we didn't make those additional 20 deliveries by the end of the year.
Okay, and follow up Mark. Given the negative CUME catches on the 320 and the 737, how much does that start to impact what you've said in the past at 42 rate? You'd be able to get back to the 16%.
margins that you made in 2018.
I would say this George and we've talked about it the last couple of calls and then some of the earnings Or some of the conferences that we've gone to
You know, the 16.5% was a good proxy back in 2016, but I would tell you today in 2023, when you think about the macroeconomic environment, when you think about the inflationary pressure is overall from a cost standpoint.
But we're going to have to evaluate that at this point in time. I think that all of those things that I just talked about are going to put pressure on our ability to achieve the 16.5% margin. We're not backing off our goals to improve our segment margins and get back to the types of cash flow that you saw in 2019 and 2018.
us. But we'll continue to, you know, as we move throughout the year, we tackle these higher production rates, you know, first things first. We've got to get our factory stable. We've got to get ourselves to casual positive. And that's what we're really focused on here in 2023. And then improving on that as we move into 2024. And, you know, we'll dialogue with you guys.
you know, every call on our progress to those plans, but at this point in time, you know, there's a lot that is taking place.
between when we had those conversations now, but our goals are continue to stretch ourselves to improve our overall profitability and make sure that we're providing great value to our investors.
when we had those conversations now, but our goals are continue to stretch ourselves to improve our overall profitability and make sure that we're providing great value to our investors. Okay, thanks very much, Mark.
Thank you, George.
We have our next question, comes from Kristi Newick from
Morgan Sone, Christine your line is now open. Hey guys, good morning. On the 420 737 MAX productions this year, can you guys talk about how you think about the inventory burn down that Boeing already has, is that factored in? So could we see true production rate and final assembly be higher?
than the 420 for the year that you have? Well, we have taken into account the inventory and the buffers. The 420 is what we will produce and deliver to Boeing and get paid for.
Now, we still have roughly 90 units or so in buffer in Wichita. Those will continue to get burned down over time, but in the meantime, they also provide a cushion to the production system as rates go up. And honestly, it's quite a useful thing to have that.
that buffer in place. Over the next two years, that buffer will get smaller at different times as Boeing's production rate exceeds spirits. But for right now, that buffer is in place and it's serving a very useful purpose to cushion the production system.
And Christine, I would just add for clarity on what we're focused on.
is the 420, it's about 20 units that we didn't deliver in 2022 will carry over.
And so we're planning on new production of 400 units.
And that's what we expect to put in ship in place and to be paid for. What Boeing delivers to their customers is we have no purview.
That's on the bowling side. We're just trying to communicate to you what contract schedules we have and what we expect to produce internally and what we expect to ship the bowling and to get paid for. So again, I think you have to separate our production from what bowling delivers because they have a production line, they have stored units. We can't really apply on what bowling is going to deliver to the customers. What we do.
question on margins. So I mean before it was you know 31 per month at break even, now with your guide for 420 per year if we just average that that's 35 per month for break even. I mean when we get out to 42 how should we think about the margin progression.
And also, you know, for when you get to the mid 40s, I mean, it sounded like you guys are walking back to 16 and a half percent segment margins. So can you give us an idea of the magnitude of change and where margins could be when you get to that mid 40s rate and stable there?
Well, what I would say is as production rates increase, margins will improve. We've certainly seen a lot of headwinds in terms of labor costs.
inflation and utilities and freight and logistics and other things in terms of supply chain. And as the production rates increase, the margins will improve. Now, at this point, there's been so much change in volatility is we're not making projections in terms of where we'll be at specific times, but they will certainly improve as the production rates increase. Thank you guys.
Thanks, thanks. Thank you, Christine.
Our next question comes from Miles Walton from Wolf Research. Miles, your lines are open.
Hey, good morning. You have Lou Raffetto on for miles. Just a couple quick cleanups here. Can you guys size the inventory charge and aftermarket in the fourth quarter?
I'm sorry that could you protect?
Sorry, can you size the inventory charge in the fourth quarter and aftermarket?
Inventory charge. Oh.
Sure, it was small. It was, we had some access and obsolete inventory that we had to dispose of in the fourth quarter. It was a couple of million dollars, two, three million dollars. If you think about aftermarket, it's 360 million of revenue. We did about 73 million dollars in the fourth quarter.
So $2 or $3 million could have a pretty big impact on the overall profitability. That probably, excluding that inventory reduction or charge that we took, after market margins would have been in excess of 20%.
All right, good. Thank you, Mark. And then just – you mentioned there's going to be a pension charge in the first quarter. Is there any way to size that as well?
You know, at this point in time, you know, we're finalizing that with our actuaries. You know, we're probably thinking somewhere between $70 and $100 million, but we're working through the final impacts of that again.
That is the non-cash component of it and then we'll also have some some tax and excise that will have to deal with this part of that closure
Okay, great. And then just last one, I guess, with all the talk about the cash impact and the margins going forward. I believe you guys have the I AM agreement that expires in June . How, if at all, are you taking that into account for the guidance for this year and just how do we think about that going forward?
potential calls increases on that. Well, our IAM agreement does expire in June .
Right, well our IAM agreement does expire on June 23rd.
and we have taken into account any potential impact in our projections that we've provided today. So we naturally have seen several other agreements that the IAM has concluded with Boeing and St. Louis, with Lockheed, with Pratt Whitney.
ULA and so forth. So we've taken into account that potential impact in our projections today. Thank you. Thank you.
We have our next question, comes from Michael Siamoli from Truist Security. Michael, your noise now open.
Hey, good morning guys. Thanks for taking the question. So I guess just thinking about this production burst deliveries, you know, it sounds like at 400 the implied rates there'd be three, but I thought you said they were going to be potentially two rate breaks. It doesn't really imply too much of a step function increase in production. I mean, is that, is that how we should look at that or are you guys?
anticipating higher monthly production rates in the second half of the year.
Well, the production rates will go up in the second half of the year, so we'll have a break to 38.
While the production rates will go up in the second half of the year, so we'll have a break to 38 and then we'll have a break to 42.
And we've taken that into account in the terms of the total number that we're going to produce this year is 420. But that's, we'll have a production rate rate, we'll go to 38 in August and 42 in October . That's the plan. And when you add it out, and I think it's important always to focus not on the rates.
but on the total numbers of deliveries. The rate break is what you're cycling at at any given point, but what really matters obviously is the total number of deliveries in a period.
Michael, I would just add that the second rate break happens very late in the year.
And so there's some investment in capital working capital that we'll have, but that rate break has very little impact on deliveries.
The benefit of the deliveries will really mostly take effect in 2024.
Got it. That makes sense. And then just another one. I mean, do you guys have any opportunities to renegotiate these contracts? I mean, we keep hearing most of the suppliers out there passing through costs, getting price increases. I mean, you guys seem to be, you know, structurally stuck here as a price taker. I mean, you mentioned the 787 pricing at line unit.
1405, I mean is there anything on the 3.7 with new blocks or are you just here for the long haul with these prices or with these contracts? Well we're always in discussions with our customers about the current market environment and the pressures that we're facing.
The 737 contract, the pricing on that is set all the way out to 2033 and it's indexed to rate as we've said in the past. But on all the programs we're always in constant discussions with all of our customers in terms of the current market conditions.
Okay, got it. Thanks for our guests. Thank you, Michael.
Our next question comes from Noah Popelike from Goldman Sachs. Noah, your lines are open.
Next question comes from Noah Popelik from Goldman Sachs. Noah, your line is now open. Hey, good morning everybody.
Good morning. Just going to stay on that max discussion.
It just want to confirm what you're saying is there are rate breaks going on in the system on the max to that 38 and that 42. But one, because you're doing them late in the year and then two, you kind of get your system there. You break there before you're actually sustainably delivering there. Here.
that those don't really generate a significant amount of units for you this year. Is that correct? In particular, the 42 a month that happens way late in the year, that is correct. Okay. But should we then think about 2024 shipments as running off of that underlying 42 rate? Yes. Okay.
We'll end the year at 42 and we'd expect to continue at that rate throughout 2024. Okay. And I mean, you know, I know there's always a little bit of a
interesting or difficult, I don't know the right word, but a dynamic of you know you don't want to get ahead of Boeing but you physically produce ahead of Boeing and Boeing wants to be conservative and cautious and everybody's still trying to figure out the health of the supply chain but I guess I'll just ask it anyway I mean how do I foot what you're saying there on max rate break
is their production rate and how they communicate, you'll have to talk to them. But what we've wanted to do here is give you what we have. I mean, these schedules have to be put in place for us long in advance. And that's the schedule that we have right now is to produce 420 units and to have two rate breaks in the back half of the year. So we just wanted to give you clarity and transparency into what our production schedule is.
Well, no, I would also think of it this way. You know, Boeing has said by 2025, they're going to go to 52 aircraft per month. So that's …
We're getting close to 18 months away from that time frame. So at some point in time in order to hit 52 aircraft per month, there's going to have to be rate breaks.
And all of that can't happen in 2024. So again, I think, you know, again, what Boeing is saying they're delivering to their customers, that's what they do. We're focused on what do we have to do to meet our contractual commitments to deliver to Boeing and what they pull from us is...
is their decision at this point in time. But again, Tom talked about two rate breaks. One of them will help us get to the 420 deliveries this year. The other one will bring people in and working capital, but the real benefit from a delivery standpoint really doesn't take place until 2024.
Okay, and maybe just one more on the topic. Is supply chain actually better? Are the bottlenecks coming to you, coming to Boeing saying, hey, we're now ready to go? Or is it you and Boeing and those that aren't bottlenecks are saying, let's just start gunning for it and that will help?
Pull the bottom X along. Yeah, no, the supply chain is better. The way I would measure it is just shortages, part shortages.
And our shortages are still elevated, as I said, two or three times higher than what they would be at steady state, but they're less than half of what they were at some points in 2022. So we've definitely seen improvement in the supply chain. Now that said, there's always about a dozen suppliers that are in deep distress that we're having to work with. And often, by the way, we're working closely with falling.
help cover and we also move work to other suppliers that have capacity to level out the system.
But the shortages are still higher than they should be, but they're less than half of what they were. And so that's why I can say there's been some improvement in the supply chain. Appreciate all the detail. Thank you.
Thank you, Raua. We have time for constraining. We have our last question from Peter Ahmet from BUID. Peter, your line is now open. Thanks so much. Hey, Tom, just quickly, just on the break.
going to 38 and eventually 42. Historically, we've always kind of understood that they're done a little more methodically, kind of at least six month increments. It seems like August and October are pretty close. Just maybe if you want to highlight how you're thinking about that or whether I'm wrong on my assumption on those rate break increments.
No, you're right. It's closer than we would normally do. But that's why we've made the investment now in getting up to the 42 headcount so that we can practice cycling there essentially all year. That'll help us do the 38 break in August and then to go to 42 in October .
So it's a little closer, but because we have the 42 heads now, which is well in advance of when we would normally have them, we were confident that we could do that and we discussed it in a lot of detail with Boeing and we both agreed that that was the right plan.
But because we have the 42 heads now, which is well in advance of when we would normally have them, we were confident that we could do that and we discussed it in a lot of detail with Boeing and we both agreed that that was the right plan. Appreciate the call and thanks, Tom.
Thank you. Thank you. We have no further questions on the line. Ladies and gentlemen, this concludes today's call. Thank you for joining me now. This corner, your lines.